Things to note before using Dongguan generator rental

Things to note before using Dongguan generator rental

existDongguan generator rentalDuring this period, users may cause equipment failure or equipment operation is not smooth due to irregular use. Therefore, merchants generally provide users with a simple user manual when renting, which contains precautions before use and also provides guidance. The specific operating procedures and steps are for the convenience and safety of generator rental.

During the rental period of Dongguan generators, there are many failures caused by improper use and failure to follow the operating procedures. On the one hand, it increases the cost of repairs and maintenance for the merchants. On the other hand, it brings inconvenience to the users of the machines, as well as frequent Improper operation reduces the service life of the machine, so inspections and steps before use are essential. Detailed precautions before use are as follows:

1. Clean the surface of the diesel generator and keep it clean.

2. Check the cooling liquid level in the water tank; the liquid level should be as close as possible to 3cm below the welding surface of the filler cover. It is recommended not to exceed it.

3. Check whether the outside of the water tank radiator core and the intercooler is blocked; if it is very dirty, it needs to be removed, remove the protective device, remove the charging valve from the unit, and then remove the intercooler from the radiator , fold it backward\/upward. Clean it with a low-concentration detergent, and be careful not to damage the upper sheet. (Remember not to wash it with high-pressure water, and install it correctly after completion)

4. Check the diesel generator air filter for clogging; if the clogging indicator is in the red zone, the filter should be replaced immediately after the unit is shut down. After replacement, press the red button to reset the indicator. Replace the air filter The filter is not allowed to be reused; during continuous operation, the filter should be checked every 8 hours. Do not move the filter until the indicator displays in the red zone.

5. Check the lubricating oil level of the diesel generator to ensure that the oil level is between the maximum and minimum values ​​of the dipstick scale. Some units can check the oil level during operation. You can use the dipstick to mark "OPERATION" Read the oil level position on one side. During continuous operation, the oil level should be checked every 8 hours. Used filters cannot be reused.

6. Check whether the electrical connections of the control system are loose. If they are loose or damaged, reconnect or replace them in time.

These precautions need to be understood clearly when renting a generator. The maintenance content of different types of units may be slightly different. The contents of this chapter are for reference only. For detailed information, please refer to the accompanying engine instruction manual and the installation and use of the generator. Maintenance manual is larger than .